2018 Ford Explorer

My vehicle has defect in the electronic power brake assist system that lead to extended stopping distances and cause me to hit someone from behind.

The contact owns a 2018 Ford Explorer. The contact started while driving at approximately 20 MPH, the check engine warning light and several unknown warning lights were illuminated. The electrical system shut down and the engine stalled. The instrument panel became inoperable. Additionally, the power steering became inoperable and the brake pedal was depressed, but failed to respond, causing the contact to lose control of the vehicle. The vehicle drove off the road and violently crashed into a ditch. The air bags failed to deploy. The contact sustained a significant whiplash and a stiff neck. The contact had not yet received medical assistance. The contact was able to exit the vehicle through the front driver's side door. The vehicle was towed to the contact's residence. There was no police report filed. The contact stated that the front passenger's side and the front undercarriage of the vehicle were significantly damaged. Additionally, the contact stated that while attempting to restart the vehicle, the vehicle emitted smoke. The contact immediately turned off the vehicle. The dealer was notified of the failure. The manufacturer was notified of the failure and advised the contact to take the vehicle to the dealer for diagnostic testing, and to call back to file a report once the VIN was available. The manufacturer also referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

When driving the car I corrected to move further to the left on the road. In doing so it felt like I ran over something and all of a sudden the car accelerated (initially I was driving around 20-25 mph) and I struck a tree. I sustained a T Spine fracture and was hospitalized for 5 days. I just have a case number with Ford but they seem disinterested. When the car accelerated I felt it was going a 2x the speed.

WE TOOK OUR 2018 FORD EXPLORER INTO THE SHOP LAST WINTER COMPLAINING OF A BAD SMELL. THE SHOP KEPT OUR CAR FOR ABOUT 5 DAYS AND SAID THERE WAS NOTHING WRONG. 2 WEEKS AGO MY WIFE WENT TO THE ER AND WAS DIAGNOSED WITH CARBON MONOXIDE POISONING. WE BEGAN WORKING WITH FOR TO HELP GET THIS FIXED, 5 DAYS LATER SHE PASSED OUT AT THE WHEEL AND WRECKED INTO A TELEPHONE POLL. WHILE AT THE ER THERE WAS CARBON MONOXIDE IN HER BLOOD AGAIN. THANK GOODNESS SHE DIDN'T HIT A FAMILY OR SOMETHING WORSE. SINCE THEN FORD HAS REFUSED TO WORK WITH US SINCE THE CAR IS WRECKED. THIS IS A PROBLEM AND NEEDS TO BE LOOKED INTO!*DT*JB*DT *TR

VEHICLE WAS STRUCK FROM BEHIND BY A PICK-UP TRUCK DRIVING AT A HIGH RATE OF SPEED. UPON IMPACT MY VEHICLE'S FRONT SEATS COLLAPSED INTO THE BACK SEATS CAUSING THE SEAT BELTS TO BE INEFFECTIVE. AS A RESULT THE PASSENGER IN MY VEHICLE SUSTAINED BACK AND NECK INJURIES. MY VEHICLE WAS STATIONARY AS THE TRAFFIC WAS AT A STANDSTILL. THE VEHICLE THAT STRUCK MY VEHICLE WAS TRAVELING AT ABOUT 70 MILES PER HOUR.

My 2018 Ford Explorer rolled backwards down a hill while in park and engine off.

I was driving on the freeway when one of my A pillers flew off and cause the person behind me to loose control of their car. About 5 min later the other a piller flew off almost causing an accident with a semi and trailer.

Around 4:45 , was unable to access cruise control the message rapidly flashed., loss of headlights and all lighting for a few seconds. Was going 70 mph. I exited the interstate to turn around and go to my work on southbound the wrench light came on and I lost power steering, power, acceleration in my turn on the on ramp and proceeded off the road onto the incline somehow avoiding a rollover and teetering sideways. Meanwhile no power to open my window etc. at an angle where I couldn’t open the door, took a minute to get out of the seatbelt. Suddenly got my window able to open and crawled out. The cops, and tow truck couldn’t believe I didn’t roll. The car was at a dealership the previous week for loss of power and terai. System problems/ no power steering and they replaced the throttle body 3 days before this happened. I’ve had multiple electrical/exhaust/power failures. I am terrified to drive this vehicle. It’s been to different dealerships and the ford ones and ford don’t care (only the dealership I purchased it at tries) it is at a fifth one now. We have forscan reports of the failures also. Multiple images at scene also. Car wouldn’t drive correctly and terrain management fault, unloaded itself from trailer too.

I have had three incidents of total brake failure on this vehicle. First, about 3 months ago I could not stop while parking in my garage and hit a work bench. I chalked it up to just a weird low speed incident as the brakes worked fine the next time I drove it. Second, I was traveling on wet roads and 27 degree weather and could not stop for a yellow light. At the time I attributed it to an icey skid because, again, the brakes worked fine the next time I needed them. But in retrospect, I do not recall any feeling that the brakes were working. Lastly, today I rear ended a car in front of me when the brakes and the supposed forward collision system both failed dramatically. I was probably going 25 MPH coming to a red light and started to apply my brakes several hundred feet before the intersection. Nothing happened and I, panicked, began pumping the pedal relentlessly. Finally the dashboard crash warning light started flashing and still no drop in speed. I tried to get into low gear, but by that time it was too late and I crashed into a van in front of me. It totaled my car and pretty well wiped out the rear doors and windows of the van. Fortunately, no one was injured. I was not cited because an EMT nurse was in the lane beside me and witnessed my brake pumping, steering wheel grabbing actions and could tell what was going on. The police are going to investigate the brake problem as well as my insurance company, USAA. There have been no brake recalls issued for my vehicle and any other recalls are up to date. There are approximately 50000 miles on it and it has had meticulous care and regular maintenance and brake shoes are still listed as good condition on my last visit for an oil change.

Driving about 50mph on dry country road, good visibility, when suddenly car pulled hard right. We went onto a grass embankment, I managed to pull left back onto the road, but car fish-tailed uncontrollably, we hit crash barrier, and finally came to a stop. Badly shaken but no injuries. Examining car, besides body damage, most notably rear drivers side wheel was mis-aligned with car by about 15 degrees. Photo of suspension I took shows broken toe-link, subsequently confirmed by body shop and loss adjuster. The car had new rear struts 2 days earlier, but at that time no report of a broken toe-link. I have subsequently learnt there is a recall for broken toe-link for Ford Explorers 2013-2017, but mine is 2018. But I suspect the recall should have been broader - my toe-link looks like one subject to recall.

The contact called in for a client who owns a 2018 Ford Explorer. The contact works at an independently owned auto body shop. The contact stated that the vehicle was towed into the body shop for inspection. While inspecting the vehicle, the contact became aware that the driver’s rear toe link had fractured. The contact stated that while the owner of the vehicle was driving at an undisclosed speed, he lost control of the vehicle and spun out, and ran off the road causing damage to the vehicle. The contact stated that he was called by the State Police to tow the vehicle. The contact was unaware of any injuries being sustained during the failure. A police report was filed. The vehicle was not yet repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 59,004.

BOTH. VEHICLES WERE MOVING. THE EXPLORER FRONT HIT THE RIGHT REAR PANEL OF A 2011 FORD RANGER. BOTH VEHICLES WERE GOING APPROXIMATELY 30 MPH. NO INJURIES SUSTAINED BY EITHER DRIVER. MY FORD EXPLORER AIR BAGS DID NOT DEPLOY. I WAS ON A CITY STREET THE OTHER VEHICLE WAS JUST BEGINNING TO TURN.

WHILE PARKING VEHICLE SUDDENLY ACCELERATED WHEN MOVING FORWARD SO MUCH THAT HAD TO TURN WHEEL TO RIGHT SIDE TO TRY TO AVOID CAR PARKED IN FRONT TO NO AVAIL HIT CAR PARKED IN FRONT WITH DRIVER SIDE BUMPER AND FENDER.THANK GOD THERE WAS LIGHT POLE IN SIDEWALK WHICH SLOWED DOWN CAR ENOUGH TO BE SHUT OFF.

I was pulling into my apartment division I heard a loud pop and the vehicle then died. I tried starting it back up and it then caught on fire. My door locks were stuck in the locked position and I could not get them to unlock. Within a few seconds (which felt like several minutes) the doors did unlock and I was able to get out. There were no warning lights or messages prior to this. Fire department did arrive and put out the fire. The car was a total loss. Report has been filed with insurance company. I purchased this car from BX Fort Myers LLC. I just purchased this vehicle from them and had for a total of 32 days. I did purchase the 12 month/12,000 mile extended warranty. I also purchased Gap insurance and informed them of what had happened. The one GM gave me a loaner for a week, got in trouble for giving me one and got demoted. the new GM said "definitely not" will not give me a loaner. I drive over an hour daily for my job and do need a vehicle.

The High-Speed Cooling Fan Motor Relay (Recall 21N01) and the Exterior A-Pillar Apical Molding (Recall 24V031) failed on my vehicle. The cooling fan caused the engine to overheat repeatedly, and the vehicle became undrivable. Unfortunately, I no longer have the vehicle, as it was surrendered to my bank and later sold at auction. However, service records, diagnostic reports, and recall information are available upon request. The overheating engine presented a significant safety risk while driving, as it could have caused the vehicle to stall or catch fire. A AAA roadside technician confirmed that the vehicle was unsafe to drive due to the overheating issue. This defect left me stranded, requiring alternative transportation and creating a hazard for others on the road had I continued driving the vehicle. Yes, the problem was confirmed by a AAA roadside technician, who performed a diagnostic scan and identified that the engine overheating was due to a defective cooling fan relay. The issue aligns with Recall 21N01. The molding defect (Recall 24V031) was not specifically inspected, but it was noted as part of the recall documentation. No, the vehicle was not inspected by Ford or any other representatives after the issues arose. I checked Ford’s website in February 2024 and learned about the recalls, but I was never notified by Ford about these safety defects while I owned the vehicle. AAA provided the only diagnostic assessment before I surrendered the vehicle to my bank. Yes, there were symptoms prior to the failure. The vehicle’s engine temperature warning light came on repeatedly, and the battery required constant recharging. The overheating symptoms first appeared in February 2024, and the vehicle became completely undrivable the next day.

Vehicle had a major mechanical issue that ignited a fire in the engine compartment. The fire quickly spread to the passenger compartment of the vehicle and totally engulfed the unit causing major damage to the entire vehicle. The vehicle is an obvious total loss.

Noticed smoke coming from vehicle as started driving vehicle, a short distance from WTS. A short time later flames were coming from behind the glove box. Driver was driving. The vehicle has not been inspected. It is unknown at this time if their were warning lamps.

TL* THE CONTACT OWNS A 2018 FORD EXPLORER. THE CONTACT ATTEMPTED TO ACCELERATE TO PASS ANOTHER VEHICLE AND NOTICED AN ABNORMAL ODOR COMING FROM THE AIR CONDITIONING VENTS. THE ODOR SMELLED SIMILAR TO BURNING FUEL. THE VEHICLE WAS TAKEN TO COURTESY FORD (LOCATED AT 1107 BRASHEAR AVE, MORGAN CITY, LA 70380, (985) 492-7260) WHERE IT WAS DIAGNOSED THAT THE ODOR EMITTED FROM THE COATING ON THE EXHAUST SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT A SMOKE TEST WAS ALSO PERFORMED ON THE VEHICLE. A REPAIR WAS MADE INSIDE THE DRIVER'S SIDE WHEEL WELL. THE CONTACT TEST DROVE TWO SEPARATE 2018 FORD EXPLORERS AND EXPERIENCED THE SAME ODOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNED A 2018 FORD EXPLORER. WHILE THE CONTACT WAS STOPPED AT A TRAFFIC LIGHT, SHE WAS INFORMED BY A PASSING MOTORIST THAT HER VEHICLE WAS ON FIRE. THE CONTACT WAS ABLE TO EXIT THE VEHICLE SAFELY BEFORE IT BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED. STATE FARM AUTO INSURANCE COMPLETED A FIRE ASSESSMENT AND STATED THAT THE FIRE WAS CAUSED BY A FAILURE WITH THE BRAKE LINES. HINES PARK FORD INC (LOCATED AT 56558 PONTIAC TRAIL, NEW HUDSON, MI 48165, (888) 482-7660) AND THE MANUFACTURER WERE NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 982.

I Drove Explorer directly to Mayo Clinic in MN shorty after the purchase. It would smell like sulpher at times, gasoline, exhaust and I was getting very poor fuel economy. Averaging 17-2. I got extremely sick and confused and had severe headaches and nausea, vertigo, congnitive impairments, burning eyes and all I wanted to do was sleep. I felt fluish and I got confused while going to Mayo for testing. Well, I didn’t make it to my appointment, I couldn’t even figure out how to book a hotel or get cash. I ended up lifeless and chose to stay in the Explorer overnight due to the severe fatigue and confusion. I slept in an open air parking garage and had an electric throw and would start the vehicle occasionally to get warm. Well I ended up so sick and mentally confused and cognitively exhausted my sister called the police to let them know something was wrong with me. I ended up in the hospital for a week. I felt like normal during my days in the hospital, I actually thought that I had been sick from the off gassing of the Explorer, but I couldn’t get away from the smells. I have MCS. After I was released I continued to drive down to Jacksonville Florida for my 3 week outpatient appointment. I was getting terrible fuel economy but I didn’t realize it until I was getting 12 miles a gallon and eventually it went as low as 5 miles per gallon. I was so sick from the odors I didn’t realize how much gas I was going through since I left CO. The Ford at that time in April 2019 had 5,000 miles on it and I was told the reason my fuel economy was so poor along with only getting 5-10 miles per gallon and the frightening smells and sickness were caused by the new emission set up and they refused to listen to my story and symptoms and charged me 500.00 to fix what looked to have been poorly installed. I now have a TBI and severe cognitive and an MRI that shows evidence of Carbon Monoxide Poisoning and things only got worse from there. Thank you.